SavedAdd your journal

Journals / Afyon Kocatepe Üniversitesi Fen ve Mühendislik Bilimleri Dergisi / 2009 / Cilt: 9 - Sayı: 3

INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS

Aylin ŞAKAR-DELİORMANLİ
Erdal ÇELİK
Mehmet POLAT
Pages
273–277
Publication Date
2009-12-01
DOI
—
🏛️Bibliographic metadata and full text access for this article are provided via DergiPark.
DergiPark Record ↗
✨

AI Summary & Key Takeaways

AI Insight
⚡ TL;DR(Too Long; Didn't Read)

Results revealed that PMN:latex ratio have some influence on the particle migration and at high latex concentrations particle clusters were observed in the supersaturated region.

📌 3 Key Takeaways

🎯
Objective & Hypothesis:Drying is a major issue in wet processing ceramics.
📊
Key Findings & Data:It has crucial effects on the final properties ceramics films especially produced by aqueous based tape casting.
💡
Conclusion & Impact:Results revealed that PMN:latex ratio have some influence on the particle migration and at high latex concentrations particle clusters were observed in the supersaturated region.
🔬Design:Research Article
📍Scope:Comprehensive Sample
⚙️Variables:Drying · tape casting · ceramic suspensions

Abstract

Drying is a major issue in wet processing ceramics. It has crucial effects on the final properties ceramics films especially produced by aqueous based tape casting. In this study structural evolution of ceramic suspension droplets were investigated during drying. Effect of binder concentration on the ring formation from droplets was tested. Results revealed that PMN:latex ratio have some influence on the particle migration and at high latex concentrations particle clusters were observed in the supersaturated region.

Özet

Drying is a major issue in wet processing ceramics. It has crucial effects on the final properties ceramics films especially produced by aqueous based tape casting. In this study structural evolution of ceramic suspension droplets were investigated during drying. Effect of binder concentration on the ring formation from droplets was tested. Results revealed that PMN:latex ratio have some influence on the particle migration and at high latex concentrations particle clusters were observed in the supersaturated region.

🔖

Cite This Article

ŞAKAR-DELİORMANLİ, A., ÇELİK, E., POLAT, M. (2009). INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS. Afyon Kocatepe Üniversitesi Fen ve Mühendislik Bilimleri Dergisi, Cilt: 9 - Sayı: 3, 273–277. https://ajindex.com/articles/452284

📄 Full Text PDF Viewer

📄

PDF görüntüleyici hazırlanıyor...

References (11)

  1. Meier, P.L., Urech L., and Gauckler, L.J., Tape Casting of Nanocrystallize Ceria Gadolinia Powder, Journal of the European Ceramic Society, Vol. 24, No.15, Pages 3753-3758, 2004.
  2. Mistler, R.E., Tape Casting: Past, Present, Potential, American Ceramic Society Bulletin, Vol.77, No.10, Pages 82-86, 1998.
  3. Chiu, R.C. and Cima, M.J., Drying of Granular Ceramic Films: II, Drying Stress, Saturation Uniformity, Journal of the American Ceramic Society, Vol. 76, Pages 2769-2777, 1993.
  4. Scherer, G.W., Theory of Drying, Journal of the American Ceramic Society, Vol. 73, No.1, Pages 3-14, 1990.
  5. Scherer, G.W., Aging and Drying of Gels, Journal of Non-Crystalline Solids, Vol. 100, Pages 77-92, 1988.
  6. Rahaman, M.N., Ceramic Processing and Sintering, (Marcel Dekker Inc., USA), 1995.
  7. Lewis, J.A., Colloidal Processing of Ceramics, Journal of the American Ceramic Society, Vol. 83, No.10, Pages 2341-59, 2000.
  8. Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Thermal Analysis and Microstructural Characterization of Ceramic Green Tapes Prepared by Aqueous Tape Casting, Journal of Thermal Analysis and Calorimetry, (In press). Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Preparation of the Pb(Mg1/3Nb2/3)O3 Films by Aqueous Tape Casting, Journal of the European Ceramic Society, ( In press). Hu, H., and Larson, R.G., Analysis of the Microfluid Flow in an Evaporating Sessile Droplet, Langmuir, Vol. 21, Pages 3963-3971, 2005.
  9. Deegan, R.D., Bakajin, O., Dupont, T.F., Huber, G., Nagel, S.R., and Witten, T.A., Capillary Flow as the Cause of Ring Strains from Dried Liquid Drops, Nature, Vol. 389, Pages 827-829, 1997.
  10. Martinez, C.J., Structure and Property Evolution during Film Formation from Binary Colloidal Suspensions, PhD Thesis, University of Illinois at Urbana Champaign, 2002.
  11. Martinez, C.J., and Lewis, J., Rheological, Structural, and Stress Evolution of Aqueous Al2O3: Latex Tape Cast Layers, Journal of the American Ceramic Society, Vol. 85, No.10, Pages 2409-16, 2002.