KaydedilenlerDerginizi ekleyin

Dergiler / Atmospheric Pollution Research / 2020 / Cilt: 11 - Sayı: 6

Experimental study on dust reduction via spraying using surfactant solution

Pengfei WANG
Quan Le Han
Chang TİAN
Ronghua LİU
Yidan JİANG
Sayfa
32–42
DOI
—
🏛️Bu makalenin bibliyografik verileri ve tam metin bağlantısı DergiPark üzerinden sağlanmıştır.
DergiPark Kaydı ↗
✨

Yapay Zeka Hızlı Bakış & Çıkarımlar

AI Insight
⚡ TL;DR(1 Cümlede Hızlı Çıkarım)

The promotion effect of surfac-tants on the dust-reduction efficiency of spraying decreased with the increase of pressure.

📌 3 Maddede Bu Makale

🎯
Amaç & Hipotez:Spraying-based dust reduction is the main technical method to prevent and control the dust coal mines.Surfactants can improve the dust reduction effect via spraying to some extent.
📊
Temel Bulgular & Veri:The experimental results showed that as the mass concentration of the sur-factant solution increased, the surface tension decreased.
💡
Sonuç & Katkı:The promotion effect of surfac-tants on the dust-reduction efficiency of spraying decreased with the increase of pressure.
🔬Tür:Araştırma Makalesi
📍Kapsam:Genişletilmiş Akademik Örneklem
⚙️Değişkenler:Alan Parametreleri

Özet

Spraying-based dust reduction is the main technical method to prevent and control the dust coal mines.Surfactants can improve the dust reduction effect via spraying to some extent. In this study, an experimentalstudy was performed to investigate the physical properties of surfactant solutions in the spray and the dust-reduction efficiency of spraying. The experimental results showed that as the mass concentration of the sur-factant solution increased, the surface tension decreased. When the surfactant concentration reached CMC, thesurface tension of the solution would not have significant decrease any more. The surfactant had no significanteffect on the dynamic viscosity of the solution. As the mass concentration of the surfactant increased, the contactangle of the droplet on the tablet surface continuously decreased. The atomization characteristics results re-vealed that the surfactant can promote the atomization effect and cause a small decrease in the droplet size onlyunder the low pressure. Under the constant pressure of 0.7 MPa, the droplet size in the sprayingfirst decreasedand then increased with the increase in the concentration of the surfactant. Overall, the droplet size did not havesignificant change. Based on the experimental results, as the surfactant concentration increased, the dust-re-duction efficiency via spraying showed a trend offirst increasing and then decreasing. In addition, although thedust-reduction efficiency was improved for both the total dust and the respirable dust by the surfactant, thepromotion effect for the latter was much more significant than for the former. The promotion effect of surfac-tants on the dust-reduction efficiency of spraying decreased with the increase of pressure.

🔖

Bu Makaleye Atıf Yap

WANG, P., Han, Q. L., TİAN, C., LİU, R., JİANG, Y. (2020). Experimental study on dust reduction via spraying using surfactant solution. Atmospheric Pollution Research, Cilt: 11 - Sayı: 6, 32–42. https://ajindex.com/articles/143944

📄 Tam Metin PDF Okuyucu

📄

PDF görüntüleyici hazırlanıyor...

Kaynakça (12)

  1. Ai, H.R., 2014. The Change law of dynamic surface tension of surfactant dampeningsolution. J. Yichun Univ. 36 (6), 29–31.
  2. Bao, Q., Nie, W., Liu, C.Q., Zhang, H.H., Zhan Wang, H.K., Jin, H., Yan, J.Y., Liu, Q., 2020.The preparation of a novel hydrogel based on crosslinked polymers for suppressing coal dusts. J. Clean. Prod. 249, 119343. Cai, P., Nie, W., Chen, D.W., Yang, S.B., Liu, Z.Q., 2019. Effect of airflow rate on pollutantdispersion pattern of coal dust particles at fully mechanized mining face based onnumerical simulation. Fuel 239, 623–635.
  3. Chen, D.W., Nie, W., Cai, P., Liu, Z.Q., 2018. The diffusion of dust in a fully-mechanizedmining face with a mining height of 7 m and the application of wet dust-collectingnets. J. Clean. Prod. 205, 463–476.
  4. Cybulski, K., Malich, B., Wieczorek, A., 2015. Evaluation of the effectiveness of coal andmine dust wetting. J. Sustain. Mining 14, 83–92.
  5. Dombrowski, N., Fraser, R.P., 1954. A photographic investigation into the disintegrationof liquid sheets. Phil. Trans. Math. Phys. Eng. Sci. 247, 101–130.
  6. Dombrowski, N., Johns, W.R., 1963. The aerodynamic instability and disintegration ofviscous liquid sheets. Chem. Eng. Sci. 18 (3), 203–214.
  7. Fan, H.M., Zhang, Y.N., Zhang, J., Wang, D.Y., Gao, J.B., Kang, W.L., Meng, X.C., Zhao, J.,Xu, hai, 2013. Dynamic surface adsorption properties of sodium dodecyl sulfateSolution. Acta Phys. Chim. Sin. 29, 351–357 02. Glanville, J.O., Haley, L.H., 1982. Study of coal dust wetting by surfactant solutions.Colloid. Surface. 4, 209–212.
  8. Han, H., Wang, P.F., Li, Y.J., Liu, R.H., Tian, C., 2020. Effect of water supply pressure onatomization characteristics and dust-reduction efficiency of internal mixing air ato-mizing nozzle. Adv. Powder Technol. 31, 252–268.https://doi.org/10.1016/j.apt.2019.10.017.
  9. Han, F.W., Zhang, J.Y., Zhao, Y., Han, J.H., 2019a. Experimental investigation on theinteraction process between coal particles and foam. AIP Adv. 9 (1), 015023.https://doi.org/10.1063/1.5080469.
  10. Hu, S.Y., Huang, Y.S., Feng, G.R., Shao, H., Liao, Q., Gao, Y., Hu, F., 2019b. Investigationon the design of atomization device for coal dust suppression in underground road-ways. Process Saf. Environ. Protect. 129, 230–237.
  11. Hu, S.Y., Liao, Q., Feng, G.R., Huang, Y.S., Shao, H., Gao, Y., Hu, F., 2020. Influences ofventilation velocity on dust dispersion in coal roadways. Powder Technol. 360,683–694.
  12. Hua, Y., Nie, W., Liu, Q., Peng, H.T., Wei, W.L., Cai, P., 2020a. The development andapplication of a