SavedAdd your journal

Journals / Sakarya University Journal of Science / 2023 / Cilt: 27 Sayı: 2

Electrospun PVDF Membranes Incorporated with Functionalized Carbon-based Material for Removal of Cationic Dyes

Fatma DEMİRCİ
Burçak KAYA ÖZSEL
Pages
386–397
Publication Date
2023-04-30
DOI
—
🏛️Bibliographic metadata and full text access for this article are provided via DergiPark.
DergiPark Record ↗
✨

AI Summary & Key Takeaways

AI Insight
⚡ TL;DR(Too Long; Didn't Read)

According to the results obtained from FTIR and differential scanning calorimetry (DSC), crystallization behavior of PVDF membranes was promoted by increasing the percentage of CBM in the membrane.

📌 3 Key Takeaways

🎯
Objective & Hypothesis:In this study, polyvinylidene fluoride (PVDF) polymeric membranes with addition of functionalized carbon-based material (CBM) were fabricated by using electrospinning technique for the removal of cationic dyes from wastewater.
📊
Key Findings & Data:According to the results obtained from FTIR and differential scanning calorimetry (DSC), crystallization behavior of PVDF membranes was promoted by increasing the percentage of CBM in the membrane.
💡
Conclusion & Impact:PVDF membrane prepared with the addition of 3 wt % CBM exhibited the highest water flux performance with a dye rejection of 74.6 % in comparison with the pure PVDF one.
🔬Design:Research Article
📍Scope:Comprehensive Sample
⚙️Variables:Electrospinning · membrane · carbon-based material

Abstract

In this study, polyvinylidene fluoride (PVDF) polymeric membranes with addition of functionalized carbon-based material (CBM) were fabricated by using electrospinning technique for the removal of cationic dyes from wastewater. CBM was prepared through a two-step carbonization process from cotton linter as an agricultural waste biomass. The characterization of CBM was performed by using Brunauer–Emmett–Teller (BET) surface analysis, fourier transform infrared spectrometry (FTIR) and elemental analysis. The morphologies of electrospun membranes were observed by scanning electron microscope (SEM) which clearly revealed that nanofibers with a smooth surface were produced by incorporation of CBM. According to the results obtained from FTIR and differential scanning calorimetry (DSC), crystallization behavior of PVDF membranes was promoted by increasing the percentage of CBM in the membrane. PVDF membrane prepared with the addition of 3 wt % CBM exhibited the highest water flux performance with a dye rejection of 74.6 % in comparison with the pure PVDF one.

🔖

Cite This Article

DEMİRCİ, F., ÖZSEL, B. K. (2023). Electrospun PVDF Membranes Incorporated with Functionalized Carbon-based Material for Removal of Cationic Dyes. Sakarya University Journal of Science, Cilt: 27 Sayı: 2, 386–397. https://ajindex.com/articles/941667

📄 Full Text PDF Viewer

📄

PDF görüntüleyici hazırlanıyor...

References (11)

  1. E. Santoso, R. Ediati, Y. Kusumawati, H. Bahruji, D. O. Sulistiono, D. Prasetyoko, “Review on recent advances of carbon based adsorbent for methylene blue removal from wastewater,” Materials Today Chemistry, vol. 16, no. 100233, 2020
  2. J. Li, L. Huang, X. Jiang, L. Zhang, X. Sun, “Preparation and characterization of ternary Cu/Cu2O/C composite: An extraordinary adsorbent for removing anionic organic dyes from water,” Chemical Engineering Journal, vol. 404, no. 127091, 2021
  3. K. B Tan, M. Vakili, B. A. Horri, P. E. Poh, A. Z. Abdullah, B. Salamatinia, “Adsorption of dyes by nanomaterials: recent developments and adsorption mechanisms,” Separation and Purification Technology, vol. 150, pp. 229-242, 2015
  4. P. Verma, S. K. Samanta, “Microwave-enhanced advanced oxidation processes for the degradation of dyes in water,” Environmental chemistry letters, vol. 16, no. 3, pp. 969-1007, 2018
  5. J. Zhao, H. Liu, P. Xue, S. Tian, S. Sun, X. Lv, “Highly-efficient PVDF adsorptive membrane filtration based on chitosan@ CNTs-COOH simultaneous removal of anionic and cationic dyes,” Carbohydrate Polymers, vol. 274, no. 118664, 2021
  6. H. D. Bouras, Z. Isik, E. B. Arikan, N. Bouras, A. Chergui, H. C. Yatmaz, N. Dizge, “Photocatalytic oxidation of azo dye solutions by impregnation of ZnO on fungi,” Biochemical Engineering Journal, vol. 146, pp. 150-159, 2019
  7. A. Nasar, F. Mashkoor, “Application of polyaniline-based adsorbents for dye removal from water and wastewater—a review,” Environmental Science and Pollution Research, vol. 26, no. 6, pp. 5333-5356, 2019
  8. F. Demirci, A. Aydın, M. Orhan, H. B. Koçer, “Production of ultrafiltration membranes exhibiting antibacterial properties by the incorporation of novel N‐halamine copolymers,” Journal of Applied Polymer Science, vol. 139, no. 31, no. e52727, 2022
  9. J. Wang, Q. Zhang, X. Shao, J. Ma, G. Tian, “Properties of magnetic carbon nanomaterials and application in removal organic dyes,” Chemosphere, vol. 207, pp. 377-384, 2018
  10. F. Baskoro, S. R. Kumar, S. J. Lue, “Grafting thin layered graphene oxide onto the surface of nonwoven/PVDF-PAA composite membrane for efficient dye and macromolecule separations,” Nanomaterials, vol. 10, no. 4, pp. 792, 2020
  11. L. Zhou, Y. He, H. Shi, G. Xiao, S. Wang, Z. Li, J. Chen, “One-pot route to synthesize HNTs@ PVDF membrane for rapid and effective separation of emulsion-oil and dyes from waste water,” Journal of hazardous materials, vol. 380, no. 120865, 2019. [1