Low Concentration NO Gas Detection Of SnO2 And Zn0.50Sn0.50O Sensors

Objective & Hypothesis:In this study, the gas sensing properties of SnO2 and Zn0.50Sn0.50O samples produced by Succession Ionic Layer Adsorption and Reaction (SILAR) method with different SILAR cycles against NO gas were investigated.

📊

Key Findings & Data:Electrical characterization of the produced sample at different temperatures (35 °C-135 °C) and different gas concentrations (50 ppb-25 ppm) were performed.

💡

Conclusion & Impact:The measurement results showed that the sensitivity of the sensors changed depending on the doping and producing cycles.

🔬Design:Research Article

📍Scope:Comprehensive Sample

⚙️Variables:Gas sensing · SILAR method · NO gas

Abstract

In this study, the gas sensing properties of SnO2 and Zn0.50Sn0.50O samples produced by Succession Ionic Layer Adsorption and Reaction (SILAR) method with different SILAR cycles against NO gas were investigated. Electrical characterization of the produced sample at different temperatures (35 °C-135 °C) and different gas concentrations (50 ppb-25 ppm) were performed. The working temperature was found at 105 °C. The sensors were proved to have acceptable responses towards 50 ppb NO gas. Zn0.50Sn0.50O sensor exhibited improved sensing performance at working temperature of 105 °C compared to SnO2 sensor.. The ,responses of SnO2 sensors for the 50 ppb NO gas concentration, sensitivities of 1.74%, 2.15% and 3.37% were obtained for 20, 30 and 40 cycles, respectively. On the other hand, the,responses of Zn0.50Sn0.50O sensors for the 50 ppb NO gas concentration sensitivities of 3.01%, 3.74% and 4.16% were obtained for 20, 30 and 40 cycles, respectively. The measurement results showed that the sensitivity of the sensors changed depending on the doping and producing cycles.

Özet

In this study, the gas sensing properties of SnO2 and Zn0.50Sn0.50O samples produced by Succession Ionic Layer Adsorption and Reaction (SILAR) method with different SILAR cycles against NO gas were investigated. Electrical characterization of the produced sample at different temperatures (35 °C-135 °C) and different gas concentrations (50 ppb-25 ppm) were performed. The working temperature was found at 105 °C. The sensors were proved to have acceptable responses towards 50 ppb NO gas. Zn0.50Sn0.50O sensor exhibited improved sensing performance at working temperature of 105 °C compared to SnO2 sensor.. The ,responses of SnO2 sensors for the 50 ppb NO gas concentration, sensitivities of 1.74%, 2.15% and 3.37% were obtained for 20, 30 and 40 cycles, respectively. On the other hand, the,responses of Zn0.50Sn0.50O sensors for the 50 ppb NO gas concentration sensitivities of 3.01%, 3.74% and 4.16% were obtained for 20, 30 and 40 cycles, respectively. The measurement results showed that the sensitivity of the sensors changed depending on the doping and producing cycles.

Keywords

Gas sensing SILAR method NO gas

🔖

Cite This Article

ER, I. K., ÇORLU, T., YILDIRIM, M. A., ATEŞ, A., ACAR, S. (2020). Low Concentration NO Gas Detection Of SnO2 And Zn0.50Sn0.50O Sensors. Politeknik Dergisi, Cilt: 23 - Sayı: 4, 1189–1196. https://ajindex.com/articles/306328

📄 Full Text PDF Viewer

Open in New Tab ↗

↗New Tab

📄

PDF görüntüleyici hazırlanıyor...

References (6)

Onofre Y.J., Catto A.C., Bernardini S., Fiorido T., Aguir K., Longo E., Mastelaro V.R., da Silva L.F., de Godoy M.P.F., Highly selective ozone gas sensor based on nanocrystalline Zn0.95Co0.05O thin film obtained via spray pyrolysis technique, Appl. Surf. Sci., 478, 347–354, (2019).[2] Gao H., Yu Q., Chen K., Sun P., Liu F., Yan X., Liu F., Lu G., Ultrasensitive gas sensor based on hollow tungsten trioxide-nickel oxide (WO3-NiO) nanoflowers for fast and selective xylene detection, J. Colloid Interface Sci., 535, 458-468, (2019).[3] Samerjai T., Channei D., Khanta C., Inyawilert K.,Liewhiran C., Wisitsoraat A., Phokharatkul D., Phanichphant S., Flame-spray-made Zn-In-O alloyed nanoparticles for NO2 gas sensing, J Alloy. Compd., 680, 711-721, (2016).[4] Bai S., Tong W., Tian Y.,Fu H.,Zhao Y.,Shu X., Luo R., Li D., Chen A., Facile synthesis of Pd-doped ZnSnO3 hierarchical microspheres for enhancing sensing properties of formaldehyde, J. Mater. Sci., 54
3, 2025–2036, (2019).[5] Karaduman I., Barin Ö., Yıldız D.E., Acar S., Atomik Tabaka Biriktirme Metodu ile Üretilen HfO2 Tabanlı Sensörlerin Hidrojen Gaz Algılama Özelliklerinin İncelenmesi, Journal of Polytechnic, 2016
19 (3): 223-229. [6] Kumar V., Singh K., Sharma J., Kumar A., Vij A., Thakur A., Zn-doped SnO2 nanostructures: structural, morphological and spectroscopic properties, J Mater. Scı.-Mater. El., 28
24, 18849–18856, (2017).[7] Saadeddin I., Hilal H.S., Pecquenard B., Marcus J., Mansouri A., Labrugere C., Subramanian M.A., Campet G., Simultaneous doping of Zn and Sb in SnO2 ceramics: Enhancement of electrical conductivity, Solid State Sci., 8
1, 7-13, (2006). [8] Guan Y., Wang D., Zhou X., Sun P., Wang H., Ma J., Lu G., Hydrothermal preparation and gas sensing properties of Zn-doped SnO2 hierarchical architectures, Sens. Actuators B, 191, 45-52, (2014).[9] Gupta P., Sharma S.K., A study of oxygen gas sensing in Zn-doped SnO2 nanostructures, Mater. Res. Express, 4, 065010, (2017).[10] Singh D., Singh Kundu V., Maan A. S., Structural, morphological and gas sensing study of zinc doped tin oxide nanoparticles synthesized via hydrothermal technique, J. Mol. Struct., 1115, 250-257, (2016). [11] Galioglu S., Karaduman I., Çorlu T., Akata B., Yıldırım M. A., Ateş A., Acar S., Zeolite A coated Zn1−XCuXO MOS sensors for NO gas detection, J. Mater. Sci.: Mater. Elektron, 29
2, 1356-1368, (2018).[12] Çorlu T., Karaduman I., Galioglu S., Akata B., Yıldırım M.A., Ates A., Acar S., Low level NO gas sens